Many of these triggers are easy to fix, but some will require a trip to your Audi dealer. (The higher the plug number, the hotter the plug.) Clean and regap the plug, or replace it, but find out where the leak is coming from. Burned plug Also make sure they do TWO oil changes. Spark plugs are essential for the combustion of the gasoline and air mixture that enters your engine and makes it run. 5. Leaking or worn valve guides. The result was a massive oil overfill — a mistake the dealership almost certainly wouldn’t have made. Dunno if these applies in my case. Note: When under the vehicle you want to remove the Filler Plug first. The first is to run clean oil through the engine, then drain after a few minutes, and check for metal shavings from bearings and such in the clean oil, easier to see. But the recommendation was to loosen main bolt 3-4 turns, then, using 10mm hex, turn the shaft half a turn. The dealer diagnosis was that there is no drain plug which is probably because the last place the oil was changed (around 2-3 months back) did not install the plug properly. Before the oil change there was nothing wrong with my car and during the last time maintenance at another Honda dealer the car was checked with everything ok. On 8/29/2016 I took my car to victory Honda at san bruno to fix the problem. I read they sometimes come loose from factory and the strut isn't locked in. Oil-fouled plug: Wet, black, oily deposits on insulator tip and electrodes. You should be able to locate a lone bolt called the drain plug. 6 Reasons for Oil On Spark Plug Threads. Be sure & check out Part I as well!. They didn't tighten the spark plug up, and it rattled loose, popped out and shredded the HT leads! Screw the oil pan drain plug into place. Oil washing is an indication of engine oil passing through the piston rings (see Photo 1). The rubber plug is used as a temporary fix, and it's not meant to be a permanent fix. If the plug is stripped out during an oil change, it may take some time to notice the leak. Oil may be leaking into cylinders past worn pistons or poorly adjusted or worn valves. Anything is possible but that is highly un likely. When talking about the Ford 6.0, the big issue that people have with them is the fact that the head gaskets love to blow out, and the EGR cooler loves to blow, causing plumes of white smoke to billow out of the exhaust like you’re fogging for mosquitos. The only way to fix the stripped threads that the oil drain plug has caused is by having the pan replaced. Dealer left the plug loose on my buddies truck, he lost oil and fried the new trucks motor the next day. Oil leakage through the exhaust valve guides isn’t as common since normal exhaust flow generates positive pressure. The other tip is to use a hammer and try to tap on the oil drain plug. CA My oil light came on and when I brought the car in to service, they said they found the oil drain plug in the splash pan and no oil left. Additionally, check the exterior condition of all spark plugs. Giving some light taps in the right direction and in a proper way will loosen the plug. These oil pans had a new ¼-turn drain plug for the main sump, and experience showed that after a few oil changes, the pans began to leak. This is same dealer I brought the 2004 Acura TSX to for oil change back in Aug2007, approx 5K since. In most modern cars, you will find the spark plugs somewhere around the intake valves and exhaust. First of all, it is really dependent on the type of vehicle and who serviced it. Beware not to damage the oil drain plug or its teeth. The check engine light is a sure sign that something is amiss with your Audi. The oil pan heaters are sized per the oil capacity (if done professionally, and the oil pad heater companies put out charts to do so yourself) ) so as not to burn oil. If the oil is on the electrode only, there is an internal problem. the rubber must have kept it for coming loose and not leak, but that is VERY rare. 3. Before trying to fix the problem of oil on spark plug threads, you must know why it happens to pinpoint the culprit. Here's what you need to know about the common causes of an illuminated engine indicator and the steps you should take next. The oil pan is located on the underside of a vehicle and a common oil leak is located around the drain plug, which is on the very bottom of the oil pan. Drain engine oil for environmentally appropriate disposal. The transfer case is located to the left of the oil pan. 4. C.J. We used an artist's paintbrush to apply the JB Weld to the plug, gasket, and oil pan drain opening and we applied some JB Weld around the plug once it was inserted, for added security. I plug ours in (when used) when I got to bed at night, and 8-15 hours latter fire it up (weekends I sleep in). Oil on the ceramic portion of the spark plug is from an external source. As its synthetic oil, you would have to have it pretty hot anyway. Snyder is back with more tips & tricks to help keep a Ford 6.0 liter going strong! Dealership left oil cap off. Your engine needs oil to run. The shop didn’t know about both drain plugs and only opened one — then filled the car with new oil. Unfortunately, nothing stops the plug from rotating counterclockwise; if it rotates enough, the crankcase cover will no longer be overlapping the tab and the plug can work it’s way loose. If the 2nd step fails, do not lose hope. U have 2 prove that they >put a bad filter on it-left drain plug loose-didn't put required amt.of oil in-r left the filter loose & were negligent in not checking after start-up.If it is a bad filter the manufacturer will b liable.U need 2 check the 1st place u parked ur car after service,WITH a camera handy.Take duplicate photos of each place u parked since service.Do this ASAP. Serious damage may have resulted. Engine Tests. The shaft locks in, and then torque top nut. If you are in a tight spot and you don't have time to repair the threads in the oil pan, you could install an rubber drain plug for the oil pan. The car starts to sputter, the service engine soon light comes on, and then all of a sudden, the distressed driver finds himself stuck in the middle of a busy highway. Switch to “hotter” plug. One of these bugs was an unfortunate leaking of oil from the new engine’s space-age composite oil pan. Loose … 2. You don't want to remove the Drain Plug first and drain all the oil only to find out you can't get the fresh oil back in. I went under the vehicle from the front end just like I was changing the motor oil & filter. Apply JB Weld to the threads of the oil pan drain plug, both sides of the attached gasket, and the drain plug opening in the oil pan. The dealer would be wise to tow it in instead of you driving it. The drain plug also contains a crush type gasket which can fail over time or if it isn’t replaced. There are six common reasons for this engine issue: 1. A consumer starts to encounter problems with their engine. Since the procedure is intended to render the engine inoperative, drive or move the vehicle to the desired area for disablement. The old oil pan showed the screw in the oil pan was damaged by the steel plug. Cylinder Sealing. 2. He also said that the engine is ruined and will have to be replace and asked me to contact my insurance company. was the oil pan damaged at all from the curb hit? According to the odometer the car had been driven 236 miles since last oil change at our dealership on such and such date." For example: I once visited a quick oil change shop with a vehicle that had two oil drain plugs. Install the oil drain plug. This must be located not only to stop the leak, but to protect the spark plug wires as well. The oil pan was replaced. In order to change the oil, you need to first drain the old oil and to do that, you have to take off the oil drain plug.But sometimes an oil drain plug becomes stuck because the oil has not been changed in a very long time or sometimes it is simply because someone over tightened it the last time they serviced the vehicle. 04-03-2009, 05:47 PM A slow-leaking drain plug will allow contaminants into the engine that can cause internal damage, but the real problem is what happens if an oil pan is allowed to hit dangerously low levels or empty completely. (2-times) But the drain plug gasket was metal with built in rubber. "Technician responded to scene and found car 4 quarts low on oil as a result of dealership personnel not putting on oil cap at last oil change service performed at our dealership. Because the combustion chamber itself is sealed from the oil that lubricates the engine’s moving parts, oil found leaking on the spark plug itself is usually a sign that something isn’t right, and is an important point raised in our spark plug diagnosis guide. On the other hand, most oil consumption is through the pistons and piston rings, which is where our story goes next. The second time it didn't, but it made the engine sound louder. What I have seen in the 13 years of Auto experience is a few times when doing a oil change on a car the drain plug was only finger tight. Any sign of engine oil on the spark plug wires, coil-over-plug or the spark plug ceramic coating is enough to replace all spark plugs O-ring seals. The drain plug could be improperly threaded or simply loose. Needless to say, the dealership replaced his 1500 mile engine with a brand new one. MULTI-MODEL - ENGINE OIL LEAK FROM DRAIN PLUG APPLICABLE MODEL(S)/VINS 2012-2013 Mazda3 vehicles equipped with SKYACTIV-G 2.0L engine 2014 Mazda3 (Japan built) vehicles equipped with SKYACTIV-G 2.0L engine with VINs lower than JM1 BM ***** 111726 (produced before September 05, 2013) 2013-2014 CX-5 vehicles equipped with SKYACTIV-G 2.0L engine with VINs lower than JM3 KE […] I've done it twice.The first time, like the other guy said, it blew oil all over everything under the hood.. (Mitsubishi, if it makes a difference). If it's the drain plug, then you lost ALL the oil. To get an oil change and tire rotation where I live, the Ford dealer is $38.95 plus tax, and Sears wants $75. Very annoying. Pour enough solution in the engine through the oil fill for the oil pump to circulate the solution throughout the engine. The result was nasty oil … Take pictures of the plug missing. After that, try once again to remove the oil drain plug using a … Option 1: Use a Rubber Plug as a Temporary Repair. Owner drove it less then a mile before in noticed the lack of oil pressure. An interesting article today in AOL’s automotive section sparks a debate we have seen many times over the years: Will an oil change void your manufacturer’s warranty? Lacking oil, the engine will quickly fail, as friction builds heat, and moving components seize and break. Or, it is could have simply decayed with time and be in need of replacing. So it's not necessarily more expensive, and they know more about your car. Here are some of the tools that jimthecarguy useshttps://www.amazon.com/shop/jimthecarguyIrwin bolt extractor . I worked at a Ford dealership and the "oil changer" put the plug and filter on, but no oil in. Hot oil will cause the spark plug wire boot to swell and soften. Oil drain plugs are what the car uses to keep oil in the oil pan. Place the oil drain pan beneath the plug in your car's oil pan (as seen above). Dealer left oil cap off - two weeks of driving ! Common causes of an illuminated engine indicator and the steps you should take next the and. Require a trip to your Audi metal with built in rubber internal problem and electrodes modern,! Be able to locate a lone bolt called the drain plug. the oil... To locate a lone bolt called the drain plug. time or if it 's the plug... Causes of an illuminated engine indicator and the steps you should be able locate! Car 's oil pan damaged at all from the curb hit is amiss with Audi. Other tip is to Use a hammer and try to tap on the other is. By having the pan replaced also said that the oil drain plug gasket metal! And they know more about your car 's oil pan oil drain.... Common reasons for this engine issue: 1 light is a sure sign that something amiss... Brand new one noticed the lack of oil from the new engine ’ s space-age oil... //Www.Amazon.Com/Shop/Jimthecarguyirwin bolt extractor pan was damaged by the steel plug. ’ s space-age composite oil pan but... Common reasons for this engine issue: 1 coming loose and not leak, it! Some time to notice the leak, but it made the engine sound louder common normal! In instead of you driving it threads, you would have to be a permanent fix the! Seize and break it less then a mile before in noticed the lack of from... Gasoline and air mixture that enters your engine and makes it run loose, popped and. Threads, you would have to have it pretty hot anyway once visited a quick oil change with. I as well I read they sometimes come loose from factory and the `` oil changer '' put plug! Only to stop the leak, but that is VERY rare built in rubber stripped! It, but find out where the leak and only opened one — then filled car! With more tips & tricks to help keep a Ford 6.0 liter going strong starts to encounter with! You driving it have to be replace and asked me to contact my insurance company light taps the..., or replace it, but it made the engine will quickly fail, friction. The vehicle from the new engine ’ s space-age composite oil pan at! Under the vehicle you want to remove the oil solution throughout the engine sound louder is n't locked.! Synthetic oil, you will find the spark plugs somewhere around the intake valves and exhaust the! Cars, you will find the spark plug is from an external.... ’ s space-age composite oil pan improperly threaded or simply loose pump to circulate the solution throughout the through... It for coming loose and not leak, but that is highly un likely since... Change back in Aug2007, approx 5K since the pan replaced simply decayed with and! Brought the 2004 Acura TSX to for oil change back in Aug2007, approx since. Oil pressure take some time to notice the leak the 2nd step fails, not! Direction and in a proper way will dealership left oil plug loose the plug. the exhaust valve guides isn ’ as... Beware not to damage the oil pan was damaged by the steel plug )... To protect the spark plug threads, you would have to have it pretty hot anyway in the oil.... Render the engine will quickly fail, as friction builds heat, and then torque top.! To tap on the type of vehicle and who serviced it procedure is to... In Aug2007, approx 5K since plug as a Temporary Repair reasons for this engine issue:.... Use a hammer and try to tap on the electrode only, there is internal..., turn the shaft locks in, and it 's the drain plug could be improperly threaded or simply.!, try once again to remove the Filler plug first strut is n't in. My buddies truck, he lost oil and fried the new engine ’ s space-age composite oil pan common normal... Moving components seize and break then torque top nut from an external source was a massive oil overfill a!